8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER 6N135 6N136 EL450X series Features * High speed 1Mbit/s * High isolation voltage between input and output (Viso=5000 Vrms ) * Guaranteed performance from 0C to 70C * Wide operating temperature range of -55C to 100C * Pb free and RoHS compliant * UL approved (No. 214129) * VDE approved (No. 132249) * SEMKO approved * NEMKO approved * DEMKO approved * FIMKO approved * CSA approved (No. 2037145) Schematic Description The 6N135, 6N136, EL4502 and EL4503 devices each 1 8 1 8 2 7 2 7 3 6 3 6 4 5 4 5 consist of an infrared emitting diode, optically coupled to a high speed photo detector transistor. A separate connection for the photodiode bias and output-transistor collector increase the speed by several orders of magnitude over conventional phototransistor couplers by reducing the base-collector capacitance of the input transistor. The devices are packaged in an 8-pin DIP package and 6N135 / 6N136 EL4502 / EL4503 Pin Configuration Pin Configuration 1. No Connection 1. No Connection 2. Anode 2. Anode * Line receivers 3. Cathode 3. Cathode * Telecommunication equipments 4. No Connection 4. No Connection * Power transistor isolation in motor drives 5. Gnd 5. Gnd * Replacement for low speed phototransistor photo couplers 6. Vout 6. Vout * Feedback loop in switch-mode power supplies 7. VB 7. No Connection * Home appliances 8. VCC 8. VCC available in wide-lead spacing and SMD option. Applications * High speed logic ground isolation Everlight Electronics Co., Ltd. Document No DPC-0000112 1 Rev.1 http://www.everlight.com October 4, 2011 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER 6N135 6N136 EL450X series Absolute Maximum Ratings (Ta=25C) Parameter Input Symbol Rating Unit Forward current IF 25 mA Peak forward current (50% duty, 1ms P.W) IFP 50 mA Peak transient current (1s P.W,300pps) IFtrans 1 A Reverse voltage VR 5 V Power dissipation PIN 45 mW Power dissipation PO 100 mW Emitter-Base reverse voltage 6N135 6N136 VEBR 5 V Base current 6N135 6N136 IB 5 mA Average Output current IO(AVG) 8 mA Peak Output current IO(PK) 16 mA Output voltage VO -0.5 to 20 V Supply voltage VCC -0.5 to 30 V VISO 5000 V rms Operating temperature TOPR -55 ~ +100 C Storage temperature TSTG -55 ~ +125 C TSOL 260 C Output Isolation voltage *1 Soldering temperature *2 Notes *1 AC for 1 minute, R.H.= 40 ~ 60% R.H. In this test, pins 1, 2, 3, 4 are shorted together, and pins 5, 6, 7, 8 are shorted together. *2 For 10 seconds. Everlight Electronics Co., Ltd. Document No DPC-0000112 2 Rev.1 http://www.everlight.com October 4, 2011 6N135 6N136 EL450X series 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER Electrical Characteristics (TA=0 to 70C unless specified otherwise) Input Parameter Symbol Min. Typ.* Max. Unit Forward voltage VF - 1.45 1.8 V IF = 16mA Reverse Voltage VR 5.0 - - V IR = 10A VF/TA - -1.9 - mV/C IF =16mA Symbol Min. Typ.* Max. Unit - 0.001 0.5 - 0.01 1 - - 50 - 140 200 - 0.01 1 - - 2 Temperature coefficient of forward voltage Conditions Output Parameter Logic High Output Current Logic Low Supply Current Logic High Supply Current IOH ICCL ICCH Conditions IF=0mA, VO=VCC=5.5V, TA=25C A IF=0mA, VO=VCC=15V, TA=25C IF=0mA, VO=VCC=15V A IF=16mA, VO=Open, VCC=15V IF=0mA, VO=Open, VCC=15V, TA=25C A IF=0mA, VO=Open, VCC=15V * Typical values at TA = 25C Everlight Electronics Co., Ltd. Document No DPC-0000112 3 Rev.1 http://www.everlight.com October 4, 2011 6N135 6N136 EL450X series 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER Transfer Characteristics (TA=0 to 70C unless specified otherwise) Parameter Symbol 6N135 Current Transfer Ratio Logic Low Output Voltage 6N136 EL4502 EL4503 Typ.* Max. 7 - 50 19 - 50 5 - - CTR 6N135 Unit Conditions IF = 16mA ,VO = 0.4V, VCC=4.5V, TA=25C % IF = 16mA ,VO = 0.4V, VCC=4.5V 6N136 EL4502 EL4503 15 - - 6N135 - 0.18 0.4 IF = 16mA ,IO = 1.1mA, VCC=4.5V, TA=25C 6N136 EL4502 EL4503 - 0.25 0.4 IF = 16mA ,IO = 3mA, VCC=4.5V, TA=25C 6N135 - - 0.5 IF = 16mA ,IO = 0.8mA, VCC=4.5V 6N136 EL4502 EL4503 - - 0.5 IF=16mA ,IO=2.4mA, VCC=4.5V VOL Everlight Electronics Co., Ltd. Document No DPC-0000112 Min. V 4 Rev.1 http://www.everlight.com October 4, 2011 6N135 6N136 EL450X series 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER Switching Characteristics (TA=0 to 70C unless specified otherwise, IF=16mA, Vcc=5V) Parameter Propagation Delay Time to Logic Low (Fig.8) Propagation Delay Time to Logic High (Fig.8) Common Mode Transient Immunity at Logic High *3 (Fig.9) Common Mode Transient Immunity at Logic Low (Fig.9)*3 Symbol 6N135 6N136 EL4502 EL4503 TPHL 6N135 TPLH Min. Typ.* Max. - 0.35 1.5 - - 2.0 Unit Conditions RL=4.1K, TA=25C RL=4.1K s - 0.35 0.8 - - 1.0 RL=1.9K - 0.5 1.5 RL=4.1K, TA=25C - - 2.0 RL=1.9K, TA=25C RL=4.1K s - 0.3 0.8 - - 1.0 1,000 - - 1,000 - - EL4503 15000 20000 - IF = 0mA , VCM=1500Vp-p, RL=1.9K, TA =25C 6N135 1,000 - - IF = 16mA , VCM=10Vp-p, RL=4.1K, TA =25C 1,000 - - 15000 20000 - 6N136 EL4502 EL4503 6N135 6N136 EL4502 6N136 EL4502 CMH CML EL4503 RL=1.9K, TA=25C RL=1.9K IF = 0mA , VCM=10Vp-p, RL=4.1K, TA =25C V/s V/s IF = 0mA , VCM=10Vp-p, RL=1.9K, TA =25C IF = 16mA , VCM=10Vp-p, RL=1.9K, TA=25C IF = 0mA , VCM=1500Vp-p, RL=1.9K, TA =25C * Typical values at TA = 25C Everlight Electronics Co., Ltd. Document No DPC-0000112 5 Rev.1 http://www.everlight.com October 4, 2011 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER 6N135 6N136 EL450X series Typical Performance Curves Everlight Electronics Co., Ltd. Document No DPC-0000112 6 Rev.1 http://www.everlight.com October 4, 2011 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER 6N135 6N136 EL450X series Figure 8 Switching Time Test Circuit & Waveform Figure 9 Transient Immunity Test Circuit & Waveform Note: *3 Common mode transient immunity in logic high level is the maximum tolerable (positive) dVcm/dt on the leading edge of the common mode pulse signal VCM, to assure that the output will remain in a logic high state (i.e., VO > 2.0V). Common mode transient immunity in logic low level is the maximum tolerable (negative) dVcm/dt on the trailing edge of the common mode pulse signal, VCM, to assure that the output will remain in a logic low state (i.e., VO < 0.8V). Everlight Electronics Co., Ltd. Document No DPC-0000112 7 Rev.1 http://www.everlight.com October 4, 2011 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER 6N135 6N136 EL450X series Order Information Part Number 6N13XY(Z)-V or EL450XY(Z)-V Note X = Part No. (X = 5 or 6) for 6N series; (X=2 or 3) for EL45 series Y = Lead form option (S, S1, M or none) Z = Tape and reel option (TA, TB or none) V = VDE (optional) Option Description Packing quantity None Standard DIP-8 45 units per tube M Wide lead bend (0.4 inch spacing) 45 units per tube S (TA) Surface mount lead form + TA tape & reel option 1000 units per reel S (TB) Surface mount lead form + TB tape & reel option 1000 units per reel S1 (TA) Surface mount lead form (low profile) + TA tape & reel option 1000 units per reel S1 (TB) Surface mount lead form (low profile) + TB tape & reel option 1000 units per reel Everlight Electronics Co., Ltd. Document No DPC-0000112 8 Rev.1 http://www.everlight.com October 4, 2011 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER 6N135 6N136 EL450X series Package Drawing (Dimensions in mm) Standard DIP Type Option M Type Everlight Electronics Co., Ltd. Document No DPC-0000112 9 Rev.1 http://www.everlight.com October 4, 2011 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER 6N135 6N136 EL450X series Option S Type Option S1 Type Everlight Electronics Co., Ltd. Document No DPC-0000112 10 Rev.1 http://www.everlight.com October 4, 2011 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER 6N135 6N136 EL450X series Recommended pad layout for surface mount leadform Device Marking EL 6N136 YWWV EL 4502 YWWV Notes 4502 6N136 denotes Device Number Y denotes 1 digit Year code WW denotes 2 digit Week code V denotes VDE (optional) Everlight Electronics Co., Ltd. Document No DPC-0000112 11 Rev.1 http://www.everlight.com October 4, 2011 6N135 6N136 EL450X series 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER Tape & Reel Packing Specifications Option TA Option TB Direction of feed from reel Direction of feed from reel Tape dimensions Dimension No. A B Do D1 E F Dimension(mm) 10.40.1 10.00.1 1.50.1 1.50.1 1.750.1 7.50.1 Dimension No. Po P1 P2 t W K Dimension(mm) 4.00.1 12.00.1 2.00.1 0.40.1 Everlight Electronics Co., Ltd. Document No DPC-0000112 12 Rev.1 16.0+0.3/ -0.1 4.50.1 http://www.everlight.com October 4, 2011 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER 6N135 6N136 EL450X series Solder Reflow Temperature Profile 260 C (peak,10 Sec Max) >255 C ( 30s Max ) 217C 1-3 C/Sec Max 200C 60 - 140 Sec 150C 70 - 170 Sec 1-3 C/Sec Max TIME (S) Everlight Electronics Co., Ltd. Document No DPC-0000112 13 Rev.1 http://www.everlight.com October 4, 2011 8 PIN DIP HIGH SPEED 1Mbit/s TRANSISTOR PHOTOCOUPLER 6N135 6N136 EL450X series DISCLAIMER 1. Above specification may be changed without notice. EVERLIGHT will reserve authority on material change for above specification. 2. When using this product, please observe the absolute maximum ratings and the instructions for using outlined in these specification sheets. EVERLIGHT assumes no responsibility for any damage resulting from use of the product which does not comply with the absolute maximum ratings and the instructions included in these specification sheets. 3. These specification sheets include materials protected under copyright of EVERLIGHT corporation. Please don't reproduce or cause anyone to reproduce them without EVERLIGHT's consent. Everlight Electronics Co., Ltd. Document No DPC-0000112 14 Rev.1 http://www.everlight.com October 4, 2011 Mouser Electronics Authorized Distributor Click to View Pricing, Inventory, Delivery & Lifecycle Information: Everlight: 6N136 6N136M 6N136M-V 6N136S(TA) 6N136S(TA)-V 6N136S(TB) 6N136S(TB)-V 6N136S1(TA) 6N136S1(TA)-V 6N136S1(TB) 6N136S1(TB)-V 6N136-V